“CABLE AND WIRES” JOURNAL - 2022 #5
Ссылка на номер в Научной электронной библиотеке ELIBRARY.RU
EDITOR-IN-CHIEF'S COLUMN
INTERVIEW
AT THE FOREFRONT OF SCIENTIFIC CHALLENGES AND ACHIEVEMENTS
Interview with V.G. Meshchanov, General Director of JSC VNIIKP, dedicated to the 75th anniversary of the Institute
SCIENCE AND TECHNOLOGY
DOI 10.52350/2072215Х_2022_5_9
MANUFACTURE OF RUTHERFORD TYPE CABLES BASED ON LOW-TEMPERATURE SUPERCONDUCTORS
L.V. Potanina, Cand. Sc. (Engineering), Leading Research Scientist, JSC VNIIKP;
V.V. Zubko, Dr. Sc. (Engineering), Chief Research Scientist of JSC VNIIKP, full member of the Academy of Electrotechnical Sciences of the RF;
K.S. Marinin, Section Manager, JSC VNIIKP;
A.A. Nosov, Cand. Sc. (Engineering), Senior Research Scientist, JSC VNIIKP;
D.S. Kaverin, Cand. Sc. (Engineering), Senior Research Scientist, JSC VNIIKP;
S.Yu. Zanegin, Cand. Sc. (Engineering), Senior Engineer, JSC VNIIKP;
S.S. Fetisov, Cand. Sc. (Engineering), Division Manager, JSC VNIIKP;
V.S. Vysotsky, Dr. Sc. (Engineering), Deputy Division Manager of JSC VNIIKP, full member of the Academy of Electrotechnical Sciences of the RF
Abstract. Due to the high engineering current density, flexibility and mechanical stability, Rutherford-type superconducting cables are widely used in the magnets of modern particle accelerators to create high magnetic fields. One of the main problems in the manufacture of Rutherford -type cables is the degradation of the current-carrying capacity and the decrease in the stability of the superconducting wires. This is largely caused by the increased deformation at the cable edges. Therefore, in the development and manufacture of such cables, certain measures should be taken to reduce the deformation of the wires at the cable edges. On the other hand, to provide the required mechanical properties, the cables must be compacted. The optimization of a balance between limiting wire deformation and the desired compaction of the cable can be achieved empirically by manufacturing and testing prototypes of the cable under development.
The paper presents a brief overview of the methods used in the development of Rutherford-type cables based on NbTi and Nb3Sn superconductors, and also summarizes the experience of their manufacture.
Key words: superconducting cables, niobium-titanium, niobium-tin, Rutherford cable
DOI 10.52350/2072215Х_2022_5_19
A.V. Babushkin, Deputy Chief Engineer, заместитель главного инженера, Moscow high voltage grid PAO “Rosseti Moscow Region”;
O.V. Romashkin, Chief Expert, Operation Department of PAO “Rosseti Moscow Region” high voltage power lines;
V.L. Ovsienko, Cand. Sc. (Engineering), Deputy Division Manager, JSC VNIIKP, associate member of the Academy of Electrotechnical Sciences of the RF;
M.Y. Shuvalov, Dr. Sc. (Engineering), Director for Research Area – Division Manager, JSC VNIIKP, full member of the Academy of Electrotechnical Sciences of the RF;
L.E. Makarov, Cand. Sc. (Engineering), Leading Research Scientist, JSC VNIIKP;
P.V. Fursov, Cand. Sc. (Engineering), Leading Research Scientist, JSC VNIIKP;
A.Z. Slavinsky, Dr. Sc. (Engineering), General Director of Ltd. “Zavod “Izolyator”;
V.B. Pshennov, Cand. Sc. (Engineering), Technical Director of Ltd. “Izolyator-AKS”;
A.A. Filippov, Production Process Engineer, Ltd. “Izolyator-AKS”
Abstract. Different trends are described for modernization of high voltage cable network equipped with high pressure pipe-type oil filled cables. Shortages and advantages of transition joints, used abroad for coupling oil-filled and XLPE-insulated cables are considered. The well-founded technical solution is selected for jointing high pressure pipe-type oil-filled cable XLPE-insulated cable with rated voltage of 110 and 220 kV, based on two transformer or GIS terminations installed in one housing.
Key words: high pressure oil-filled cable system, life time, cable installation, transition joint, three-phase and single-phase joint construction, electric test
DOI 10.52350/2072215Х_2022_5_27
INVESTIGATION OF MUTUAL INTERFERENCE AT THE FAR END OF MULTI-PAIR LAN CABLES
V.V. Bannov, Cand. Sc. (Engineering), Deputy General Director, Technical Director, JSC “Samara Cable Company”;
A.N. Nekrasov, Chief Technologist, JSC “Samara Cable Company”;
V.V. Smirnova, Leading Manager, JSC “Samara Cable Company”;
B.V. Popov, Cand. Sc. (Engineering), Professor of Communication Lines Department, Povolzhsky State University of Telecommunications and Informatics;
V.B. Popov, Cand. Sc. (Engineering), Professor of Communication Lines Department, Povolzhsky State University of Telecommunications and Informatics
Abstract. The article presents the results of investigation of the parameters of mutual influences at the far end of multi-pair LAN cables. The obtained data on the predominant components of mutual influence allow taking measures aimed at the reduction of mutual interference between the cable circuits at the stage of cable designing and manufacture. Based on the conducted investigations, a set of measures related to the multi-pair LAN cable manufacturing technology was developed which ensured the compliance with the requirements for category 5e cables.
Key words: multi-pair LAN cables, parameters of mutual influences, mutual interference at the far end
ECONOMY
DOI 10.52350/2072215Х_2022_5_31
RUSSIAN-CHINESE ECONOMIC COOPERATION: OPPORTUNITIES AND OBSTACLES IN THE NEW ENVIRONMENT
E.B. Vasiliev, Cand. Sc. (Economics), Chairman of Board of Directors, JSC VNIIKP, full member of the Academy of Electrotechnical Sciences of the RF;
A.A. Meshalkin, Leading Specialist for IEA,JSCcl. Trade House of VNIIKP
Abstract. Analysis of Russian-Chinese economic cooperation. A review of the report presented by comrade Wilson Ling, Deputy Director General of the Shanghai Electric Cable Research Institute (SECRI), at the general meeting of the "Electrocable" Association has been done.
Key words: Russian and Chinese cable industry, Shanghai Electric Cable Research Institute (SECRI), Asian Wire & Cable Industrial Cooperation Alliance (AWCCA), export-import operations, cross-border transport network, trade relations between Russia and China
INDUSTRY NEWS
CABLE INDUSTRY 2022. RESULTS OF THE 80th GENERAL MEETING OF THE ELECTROCABLE ASSOCIATION
E.B. Vasiliev, Cand. Sc. (Economics), Chairman of Board of Directors, JSC VNIIKP, Vice-President of the Electrocable Association, full member of the Academy of Electrotechnical Sciences of the RF
XIX INTERNATIONAL CONFERENCE ICEEE-2022
S.V. Serebryannikov, Dr. Sc. (Engineering), Chairman of ICEEE-2022 conference, Professor of FGBOU VO “NIU “MEI”, full member of the Academy of Electrotechnical Sciences of the RF
PAGES OF HISTORY
JUBILEES
KAMENSKY M.K. celebrated his 80th birthday
MESHCHANOV V.G. celebrated his 60th
POCHUEV A.M. celebrated his 65th birthday
OVCHINNIKOVA I.A. celebrated her 50th birthday
GNYPA S.I. celebrated his 60th birthday
OBITUARY